卡特故障代碼
Engine Control 發動機控制器 (MID No. 036)
CID Component 元件
0001 Injector Solenoid 1st Cylinder 1#缸噴油器電磁閥
0002 Injector Solenoid 2nd Cylinder 2#缸噴油器電磁閥
0003 Injector Solenoid 3rd Cylinder 3#缸噴油器電磁閥
0004 Injector Solenoid 4th Cylinder 4#缸噴油器電磁閥
0005 Injector Solenoid 5th Cylinder 5#缸噴油器電磁閥
0006 Injector Solenoid 6th Cylinder 6#缸噴油器電磁閥
0041 8V DC
Supply挖掘機維修|挖掘機修理|維修挖掘機|修理挖掘機8V直流電源
0042 Injection Actuation Control Valve 噴油器促動控制閥
0091 Throttle Position Signal 油門位置信號
0094 Fuel Pressure Sensor 燃油壓力國傳感器
0100 Engine Oil Pressure Sensor 發動機機油壓力傳感器
0110 Engine Coolant Temperature Sensor 發動機冷卻液溫度傳感器
0164 Injector Actuation Pressure 噴油器促動壓力
0168 System Voltage 系統電壓
0172 Intake Manifold Air Temperature 進氣岐管空氣溫度
0175 Engine Oil Temperature Sensor 發動機機油溫度傳感器
0190 Engine Speed Sensor 發動機速度傳感器
0253 Personality Module 個性模塊
0261 Engine Timing Calibration 發動機正時校驗
0262 5V Sensor DC Power Supply 5V傳感器直流電源
0268 Check Programable Parameters 檢查可編程參數
0273 Turbo Outlet Pressure Sensor 渦輪增壓器出口壓力傳感器
0274 Atmospheric Pressure Sensor 大氣壓力傳感器
0286 Oil Lamp 機油燈
0342 Secondary Engine Speed Sensor 次級發動機速度傳感器
0617 Air Inlet Heater Relay 空氣進氣加熱繼電器
1627 Fuel Pump Relay 燃油泵繼電器
Engine / Pump Control 發動機/泵控制器 (MID No. 105)
CID Component 元件
0091 Throttle Position Signal 油門位置信號
0096 Fuel Level Sensor 燃油油位傳感器
0110 Engine Coolant Temperature Sensor 發動機冷卻液溫度傳感器
0167 Alternator 發電機
0168 Voltage Of The Power Supply (Keyswitch) 鑰匙門電壓
0190 Speed Sensor 速度傳感器
0248 Cat Data Link CAT數據線
0286 Signal For Low Engine Oil Pressure 發動機機油壓力低信號
0374 Swing Brake Solenoid 回轉制動電磁閥
0376 Travel Alarm 行走警報
0581 "Proportional Reducing Valve For The Powershift Pressure" 動力換檔比例減壓閥
0586 Engine Speed Dial 發動機速度盤式開關
0587 Feedback Sensor For The Governor Actuator 調節器傳動裝置反饋信號
0590 Engine Controller 發動機控制器
0598 Travel Speed Solenoid 行走速度電磁閥
0600 Hydraulic Oil Temperature Sensor 液壓油溫傳感器
1161 Pump Delivery Pressure 泵壓
1162 Pump Delivery Pressure 泵壓
1524 "Proportional Solenoid Valve For
Negative Flow Control" 負流量控制比例電磁閥
1525 Straight Travel Solenoid 直線行走電磁閥
1590 "Proportional Solenoid Valve For
Negative Flow Control" 負流量控制比例電磁閥
2002 Action Alarm 警報
FMI 故障描述
0 Data valid but above normal operationl range 數據正確，但高于正常范圍
1 Data valid but below normal operationl range 數據正確，但低于正常范圍
2 Data erratic,intermittent ,or incorrect 數據不穩，斷續或不正確
3 Voltage above normal or shorted high 電壓高于正常或突然高
4 Voltage below normal or shorted low 電壓低于正?；蛲蝗坏?/span>
5 Current below normal or open circuit 電流低于正?；蜷_路
6 Current above normal or grounded circuit 電流高于正常或短路
7 Mechanical system not responding properly. 機器系統沒有正確反應
8 Abnormal frequency, pulse width, or period. 異常頻率、脈沖或周期
9 Abnormal update. 異常更新
10 Abnormal rate of change. 異常變化率
11 Failure mode not identifiable. 故障模式不能確認
12 Bad device or component. 壞的設備或元件
13 Out of calibration. 超出校驗范圍
14-31 Reserved 保留事件代碼
Event Codes 事件代碼
Engine / Pump Control 發動機/泵控制器
Event Code Condition
017 Coolant Overheat 冷卻液高溫
043 "Abnormal Battery Charge
(Voltage To Power Supply Low)" 電壓異常（電壓低）
050 "Abnormal Battery Charge
(Voltage To Power Supply High)" 電壓異常（電壓高）
059 Insufficient Level Of Coolant 冷卻液不足
095 Fuel Filter Is Clogged 燃油濾芯堵塞
100 Engine Oil Pressure Is Low 發動機機油壓力低
119 Fuel Level Is Low 燃油油位低
171 Engine Oil Level Is Low 發動機機油油位低
179 "Abnormal Battery Charge
(Charging Is Abnormal)" 電瓶充電異常
232 Water Separator Draining Demand 油水分離器需排水
235 Hydraulic Oil Level Is Low 液壓油位低
236 Hydraulic Oil Filter Is Clogged 液壓油濾芯堵塞
237 Overload Warning 過載警報
272 Air Filter Is Clogged 空氣濾芯堵塞
600 Hydraulic Oil Overheat 液壓油高溫
862 Special Filter Is Clogged 專用濾芯堵塞
863 Automatic Greasing Failure 油脂自動注油失敗
Event Codes 事件代碼
Engine Control 發動機控制器
Event Code Condition
005 Fuel Filter Restriction Derate 燃油濾芯堵塞減額
015 High Engine Coolant Temperature Derate 冷卻液高溫減額
017 High Engine Coolant Temperature Warning 冷卻液高溫警報
025 High Inlet Air Temperature Derate 進氣溫度高減額
027 High Inlet Air Temperature Warning 進氣溫度高警報
039 Low Engine Oil Pressure Derate 機油壓力低減額
096 High Fuel Pressure 燃油壓力高
100 Low Engine Oil Pressure Warning 發動機機油壓力低警報
190 Engine Overspeed Warning 發動機超速警報
265 User Defined Shutdown 用戶自定義熄火
